Monday, February 23, 2009

Fireplace Install

I've been working on installing the new fireplace pretty much non-stop lately. Worked on it all weekend from when I woke up until I went to bed at night. It started with alot of demolition, I had to cut out a 4-1/2 foot wide opening that was 8 feet tall in the living room wall. This is the wall that the old chimney ran up through.

Here's standing inside the boys bedroom looking out into the living room through the giant hole that I'm creating. Its pretty amazing how much work was actually involved in "making a hole in a wall".


Making an opening that big required cutting out some wall studs. After I supported the wall properly, I cut the studs out and then framed in a double 2x8 header that you see at the top of the photo. This header is supported on each side by 2 - 2x4 studs and carries the weight from the studs above that were cut off. You can also see a gas line and electric wire in the wall there that I had to relocate.


Here is a side view after the wall was completely removed, I also had to remove 2' off the side wall in the bedroom to maintain my proper clearance from the fireplace. On the floor I'm starting to frame out the platform the fireplace will be sitting on. You can also see the floor where I patched it up. Where the hammer is laying used to be the opening the brick chimney ran through down into the basement.


My dad and brother helped move the fireplace into position and I began installing the chimney pipe from there, the pieces just twist-lock together and about every 5 feet I install a wall clamp. I still need to build a hearth out in front of the fireplace and also frame in the walls around the fireplace with metal studs.


Up in the attic, the new chimney pipe runs up through the old masonry section I left above the roof line. Eventually I will frame this all out so the pipe is enclosed. Also you can see one of the wall straps in this pic.

3 comments:

Anonymous said...

that bad boys gonna throw off some heat!!!!!!!!!!!!!!!!!!!!!!!!!!!!

Anonymous said...

So much work......you'll be rewarded with a great home....

Vagabond said...

Are you gonna teach Zander and Miles to chop wood??

statistics history
Dell Computers